Ford Expedition Structure Problems
- 100
- Owner complaint records in our dataset
- 11
- Years with records
- 1999–2010
- Stored years
Records are owner complaints, not a measured failure rate.
Owner complaint recordsComplaint records reflect reports in our dataset and do not measure how frequently the problem occurs across all vehicles.
Among these 100 stored complaint records:
- 4 indicate a crash
- 6 indicate injury
- 4 indicate fire
- 1 indicate a death
Complaints by year
What appears in the records
- windshield wipers · 14 records
- spare tire · 10 records
- water leak · 9 records
- front windshield · 6 records
- eddie bauer · 6 records
- electrical problems · 6 records
Mileage in stored records
| Band | Records |
|---|---|
| 60–100k mi | 21 |
| 100–150k mi | 14 |
| 30–60k mi | 13 |
| 1–30k mi | 11 |
| 150–400k mi | 1 |
Complaint evidence
Latest stored owner-submitted records. Open a year for the full list.
Structure
PAINT IS CRACKING. *TR
ODI 10641154
Structure
Paint failure ref. Tsb# 06-25-15 [xxx] information redacted pursuant to the freedom of information act (foia), 5 u.s.c. 552(b)(6). *tr
ODI 10680389
Structure
Bubbling of paint located centrally on tailgate in several locations around metal edge and around license plate, is apparently not covered under warranties or purchased $3500 extended warranty coverage either...nice ford! *tr
ODI 10629478
Engine · Fuel System, Gasoline · Power Train · Structure
Was driving down off ramp lost all power to the vehicle, no steering, no brakes. I had my 3 children in the vehicle with me and thankfully i was able to cost to the shoulder until help arrived. Extremely scary had it happen 2 minutes earlier would of been off the ramp and into oncoming traffic! This is unacceptable!! My mechanic says it's the fuel pump, and just the part is 500 dollars?!? This could of ended very…
ODI 10584466
Structure
Rust in the channels of the roof has penetrated completely through the sheet metal. Vehicle has been well maintained and is otherwise in perfect condition. *tr
ODI 10573806
Electrical System · Structure · Visibility/Wiper
Summary: water leaked around the left side of windshield causing electrical failures, including but not limited to the starter, radio, windshield wipers, headlamps, etc. The water entering the vehicle wet the power distribution box (pdb) and the generic electronic module (gem). These components control various electrical systems in the vehicle. The vehicle continued to attempt to start itself without any key in…
Fire reported
ODI 10664194
Structure
Paint is blistering on the hood and rear tailgate, which are made of aluminum. Ford won't cover this under their corrosion warranty unless there is perforation thru to the sheet metal. By the time this occurs the warranty is up and the paint is falling off the vehicle. *tr
ODI 10605219
Structure · Unknown Or Other
While driving approximately 20 mph on a rural road the spare tire fell out from under the vehicle, onto the road. I discovered the cable that holds the spare tire in place under the vehicle had broken. *js
ODI 10598350