2002 Ford Expedition Suspension Problems
- 9
- Owner complaint records in our dataset
Records are owner complaints, not a measured failure rate.
Owner complaint recordsComplaint records reflect reports in our dataset and do not measure how frequently the problem occurs across all vehicles.
Mileage in stored records
| Band | Records |
|---|---|
| 150–400k mi | 2 |
| 100–150k mi | 2 |
| 60–100k mi | 1 |
| 1–30k mi | 1 |
| 30–60k mi | 1 |
Complaint records
Owner-submitted complaint content, presented as stored.
Fuel/Propulsion System · Seat Belts · Suspension
Two weeks before this problem happen ,the truck starts making tomuch noise and air supention didn't go up no more . And stop making noise .
ODI 11253901
Suspension
Takata recall during an inspection of my suspension for worn bushings, i noted severe corrosion on my rear trailing arms for the rear axle. The lower arm on the passenger side actually had a quarter size hole in the inboard side of the web. This obviously greatly reduces the strength of the arms and could cause axle separation from the vehicle and an obvious control hazard.
ODI 10981416
Suspension · Wheels
Tl* the contact owns a 2002 ford expedition. While driving at low speeds and attempting to accelerate, the tires wobbled. In addition, the front and rear of the vehicle were unstable. The vehicle was taken to an independent mechanic who stated that all four rims were bent. The vehicle was taken to another independent mechanic who diagnosed that the belts and bands were worn for all four tires and that all four tires…
ODI 10749213
Suspension
Had routine service on my 2002 expedition at dealership,was told i needed to replac upper and lower trailing arm also track arm because of severe corrosion.
ODI 10522113
Body · Suspension · Unknown Or Other
During inspection it was noticed that the upper and lower rear control arms were rusted through and unsafe. Had them replaced including the rusted through shocks. Hood and roof paint shows serious paint peeling and bubbling. *tr
ODI 10565491
Suspension
Tl* the contact owns a 2002 ford expedition. The contact noticed something leaking from under the vehicle. Also, while the vehicle was in operation it would bounce up and down abnormally. Neither the dealer nor the manufacturer were notified of the failure nor was the vehicle diagnosed or repaired. The current mileage was 202,000. The approximate failure mileage was 185,000.
ODI 10426523
Power Train · Structure · Suspension
Ford expedition failed suspension system repair request under warranty.*mr the consumer's believed the suspension system is faulty. The consumer contacted the manufacturer but they refused any assistance. *nm the transmission started with an occasional chunk and or ratcheting sound, rough, did not move and would bang when moved, the driver window occasionally rolled up out of the top rack and there was air leakage,…
ODI 10083708
Gasoline · Module · Suspension · Tank Assembly
The consumer stated that four days after purchase, the vehicle vibrated and lunged side to side, the tires were balanced to try and correct the problem, however the problem was still not resolved.*yh
ODI 567578
Suspension
While driving at highway speeds the vehicle will start to vibrate at steering wheel, causing some trouble for consumer on controlling vehicle. Contacted dealer, and the dealer was aware of problem, but had no remedy for problem.*ak
ODI 8012032