2004 Ford Expedition Unknown Or Other Problems
- 11
- Owner complaint records in our dataset
Records are owner complaints, not a measured failure rate.
Owner complaint recordsComplaint records reflect reports in our dataset and do not measure how frequently the problem occurs across all vehicles.
Mileage in stored records
| Band | Records |
|---|---|
| 100–150k mi | 4 |
| 60–100k mi | 2 |
| 150–400k mi | 2 |
| 1–30k mi | 1 |
| 30–60k mi | 1 |
Complaint records
Owner-submitted complaint content, presented as stored.
Unknown Or Other
My dash vents are not sending any a/c out the front vents, and i also feel heat from the floor board of my car along with exhaust emissions. I know that the san diego police had the same problem with their expeditions and they were recalled and repaired,now they changed to ford explorers . Is there anything still on the books for the expeditions? The vehicle can be in any function,it is just not working, and also i…
ODI 11219895
Body · Suspension · Unknown Or Other
Rusted out rocker panels, brake lines, front end radiator mounts, fender mounts. The entire under carriage is rusting away. We have had to replace all the brake lines as they have rusted away, redid the rocker panels rust away. Now we have to replace the entire front end because of rust. Will not pass pa state inspection due to rust. Is the expedition in the recall for rust?
ODI 11130883
Unknown Or Other
Vehicle stalls while driving in traffic, stops and will not start for 2-3 days. After 2-3 days vehicle starts back with no problem, but in a couple of days does the same thing all over again.
ODI 10915739
Engine · Fuel/Propulsion System · Unknown Or Other
While driving in the city on local streets, the engine just stops with no ability to drive. I am an instant safety problem on the road. This happened 3 times in one day. Fortunately, no one was injured. After a few minutes, the car starts up again. My mechanic can't duplicate the problem. Anyone help before there is a major life-threatening accident!! Thanks!
ODI 10884825
Electrical System · Unknown Or Other
This has occurred a three times in last month...first being in july. I park my vehicle, turn ignition off and pull out key and the air conditioner is still blowing and radio is still going for a couple seconds after key is pulled out...only a couple seconds and immediately shuts itself off. This is definitely an electrical or ignition issue.i do know radio will stay on until door opened, thats a feature of the…
ODI 10762386
Engine · Fuel/Propulsion System · Unknown Or Other
Our 2004 ford expedition eddie bauer suddenly turns off while we are driving at any speed. In a year's time, it has turned off four or more times. Most of those times, we were traveling at speeds of about 60mph. All of the power shuts off, steering and brakes included. We turn the key off and it does restart. Luckily we have not been in any terrible accidents!
ODI 10875319
Body · Suspension · Unknown Or Other
My truck has started making a very loud noise coming from the front under side of the vehicle. Upon further investigation we have discovered that there was excessive rust and corrosion on the frame. This has caused parts of the engine to shift and rub/ collide with other parts and cause the noises. Our mechanic and my husband both feel that the rust and corrosion have made the vehicle unsafe to drive. There is no…
ODI 10538142
Electrical System · Unknown Or Other
I am the 2nd owner of this vehicle. Had problem w/ drivers seat & mirror fuse blowing out since i purchased truck in august 2011. Some time in 2012 i started having additional problems w/ my truck like radio &/or heating/air not coming on when started. Check engine light going on & off & back windshield wiper stopped working. Then it was the vehicle was dying quickly by leaving the radio on for 10 min after vehicle…
ODI 10723406
Body · Unknown Or Other
Tl* the contact owns a 2004 ford expedition. The paint near the front hood, the rear lift gate, the door latch and the wind-shield wiper has corroded. The vehicle has not been inspected or repaired for the failure. The failure mileage was 90,000. The current mileage was 93,000. Updated 11/12/09 *cn the consumer stated the vehicle has never been in an accident. The vehicle is stored in a garage overnight. Updated…
ODI 10287424
Unknown Or Other
DOOR SIDE GUARDS FINISH IS FADING. *NM
ODI 10154884
Unknown Or Other
At 500 miles the new driver floorboard had a vibration and grinding noise when the wheel was turned while driving. The dealer kept my car for 2 days and changed out the differentals and packed it with a "fix" from ford. Driving home from the dealer my car still experienced the same vibrations and grinding. The dealer advised me to drive it 1,000 miles and then return it if it still had turning and grinding. I…
ODI 10058490