2005 Ford Expedition Fuel/Propulsion System Problems
- 20
- Owner complaint records in our dataset
Records are owner complaints, not a measured failure rate.
Owner complaint recordsComplaint records reflect reports in our dataset and do not measure how frequently the problem occurs across all vehicles.
What owners report
- fuel pump · 6 records
- warning light · 4 records
- electronic throttle · 4 records
- throttle control · 4 records
Mileage in stored records
| Band | Records |
|---|---|
| 100–150k mi | 10 |
| 60–100k mi | 3 |
| 150–400k mi | 2 |
| 1–30k mi | 1 |
Complaint records
Owner-submitted complaint content, presented as stored.
Electrical System · Fuel/Propulsion System
Crank no start, after replaced new fuel pump, filter and other parts would not start and not getting fuel. Was in motion and died after making a right turn after filling fuel tank.
ODI 11057474
Fuel/Propulsion System · Visibility/Wiper · Wheels
Tl* the contact owns a 2005 ford expedition. The contact stated that while driving at 65 mph, the fuel cap and the tire sensor warning light illuminated. The vehicle was taken to the dealer (capital ford of charlotte located at 5411 n tryon st, charlotte, nc 28213) where it was diagnosed that the tire sensor, the fuel cap and the windshield wiper blade needed to be replaced. The vehicle was repaired. The contact…
ODI 11034775
Electrical System · Fuel/Propulsion System
Fuel pump driver module failed due to design flaw which caused galvanic corrosion. Aluminum body of component acts as the sacrificial anode for the frame which is steel. This caused my vehicle to stall at 65mph and lose power and thus caused the loss of power steering and hydraulic brake booster while traveling a high rate of speed. This could be especially dangerous on highways, congested areas, or areas with…
ODI 11010674
Electrical System · Engine · Fuel/Propulsion System
This car just numerous of problem..... Who ever built this car did not have a good job of doing it
ODI 10928624
Fuel/Propulsion System
My suv was parked in parking lot of a store. Smoke started coming out from my vehicle. Then it started to catch on fire. Fire fighters said the fire started from the fuel injectors.
ODI 10924635
Engine · Fuel/Propulsion System
For many time that my expedition has stalled because of the throttle body failing. The engine goes into safe mode and stalls and stops, thi is very danger situation
ODI 10873914
Body · Fuel/Propulsion System · Power Train
Transmission bad ,paint come out some areas, replace all the spark plugs
ODI 10862924
Engine · Fuel/Propulsion System
Electronic throttle control help, i have a 2005 expedition,. The thing has just started shutting down on me while driving. For no apparent reason, while driving along, it stops running, and after shutting it off, placing it in park, it will start back up. It was so scary , thanks god i didn't had any accident ,this is a big issue from ford *js
ODI 10592264
Fuel/Propulsion System · Vehicle Speed Control
While setting at a stop light a warning message came on about checking electronic throttle control. When i release the brake to accelerate when the light turned green i coasted into the intersection only to find that the accelerator peddle had no response. Fortunately the engine idle was enough to get me through the intersection before the light turned red. I then coasted to the nearest parking lot and shut the…
ODI 10577352
Engine · Fuel/Propulsion System
While driving the vehicle went into a heavy vibration from the motor and the smell of raw fuel was present. After turning off the vehicle it would not start. The vehicle was towed to the ford dealer and the dealer stated that a fuel injector became stuck open. The injector filled the cylinder with fuel and caused the engine to blow up (severe damage). It was found that this occurred on ford expeditions numerous…
ODI 10681481
Fuel/Propulsion System
Tl* the contact owns a 2005 ford expedition. The contact stated that while traveling 60 mph, the vehicle suddenly stalled. The vehicle was taken to a private mechanic where it was found that the driver fuel module needed to be replaced. The vehicle was repaired. The manufacturer was not contacted about the failure. The failure mileage was approximately 108,000.
ODI 10562068
Fuel/Propulsion System · Vehicle Speed Control
Driving on i-75 at 78 mph my car just shut off. I had no power and nearly was involved in a 18 wheeler hitting me. The "check electronic throttle control" warning light came on but after the engine quit. Once i calmed down the car started right back up. I just had my second issue with the same warning light and engine power shutting off. I had to coast through a very busy intersection. Then the car started right…
ODI 10544442
Fuel/Propulsion System
Was driving when check electronic control sensor came on and with out warning vehicle died in middle of road. *tr
ODI 10522451
Electrical System · Engine · Fuel/Propulsion System
While driving along at 55 mph engine shut down. No power brakes, steering, etc. Indicator message on dashboard said "check electronic ignition". Repair cost $ 724.19. *tr
ODI 10681465
Fuel/Propulsion System
While i was driving done the interstate, my ford expedition lost all power and completely stalled. Luckily, i was able to get it off the road to the shoulder without any incident. This is the third time it has happened to me. Previously, i had my fuel pump sensor changed because my check engine light came on and that is what it indicated; however, the problem still exits and my mechanics are baffled. Very dangerous!…
ODI 10496131
Fuel/Propulsion System
While traveling down the freeway at 70 mph, the vehicle died. It would not restart. After 1 hour vehicle the vehicle started and then died within seconds. The fuel filter and fuel pump were replaced because all indications lead to believe that the fuel pump was bad. After replacement of the fuel pump, vehicle would not start. Looking on the internet for possible solutions from others, i found one person with the…
ODI 10493505
Engine · Fuel/Propulsion System
I was driving down the center lane on rt 41 in port charlotte, with an approximate speed of 45 mph, when the engine just shut down. This is not the first time it happened to me, and it's very dangerous. I had to maneuver carefully to pull over to the side of the road, with cars beeping, and swerving around me. I tried to restart the vehicle, but kept getting an "engine fail safe mode" message. I sat for a while on…
ODI 10475902
Engine · Fuel/Propulsion System
Tl* the contact owns a 2005 ford expedition. The contact stated that the engine stalled without warning while driving at any speed. The engine failure mode light illuminated after the failure occurred. The failure was experienced several times. The vehicle was taken to a local mechanic, who replaced the fuel filters and the injector but the failure was not corrected. The vehicle was then taken to an authorized…
ODI 10466636
Fuel/Propulsion System · Power Train · Vehicle Speed Control
I have a 2005 expedition and have had a electronic throttle control failure on it twice in the last 10 months. Both cases happened while turning through a major intersection, the engine continued to run, but there was no connection between the gas pedal and the throttle (stepping on the gas had no effect). Luckily i was able to coast through the intersection and onto the shoulder without getting hit. The first…
ODI 10478146
Fuel/Propulsion System
The reported model was cruising at 65 miles an hour along north bound i-795 @ nc rte 42, wilson, nc (state police responded to this disabled vehicle call) vehicle acted like it ran out of gas. Electrical proveout indicators were normal. Ignition system was functional, as were all other facets of the electrical system seemed fine during the engine power failure, however , loss of steering power and braking power was…
ODI 10577711