1. Ford Expedition
  2. Problems
  3. 2006
  4. Engine And Engine Cooling

2006 Ford Expedition Engine And Engine Cooling Problems

61
Owner complaint records in our dataset

Records are owner complaints, not a measured failure rate.

Owner complaint recordsComplaint records reflect reports in our dataset and do not measure how frequently the problem occurs across all vehicles.

Among these 61 stored complaint records:

  • 0 indicate a crash
  • 1 indicate injury
  • 1 indicate fire

What owners report

  • fail safe · 24 records
  • safe mode · 20 records
  • engine fail · 14 records
  • failure mileage · 11 records
  • failure current · 10 records
  • spark plugs · 9 records

Mileage in stored records

BandRecords
60–100k mi29
30–60k mi17
1–30k mi5
100–150k mi4
150–400k mi2

Complaint records

Owner-submitted complaint content, presented as stored.

  • July 3, 2013 · 93,000 miles

    Engine And Engine Cooling

    I believe that ford expeditions from years 2003 - 2006 have a serious defect. I am experiencing radiator support mount rot. My mechanic says this should not be occurring on a vehicle that is only 6 years old. I have done some research and have read on the ford expedition forum that many expedition drivers are now finding this to be the case with their vehicles as well. I seriously believe a recall should be in place…

    ODI 10523121

  • July 18, 2012 · 98,000 miles

    Engine And Engine Cooling · Fuel/Propulsion System

    3rd time problems with spark plugs and fuel injector....was told by dealer that this year model the injectors are bad for sticking....leaving the owner to pay for repair cost and the expense of changing fords faulty spark plugs. *tr

    ODI 10466586

  • May 1, 2012 · 83,533 miles

    Engine And Engine Cooling

    I was on hwy doing 55 getting ready to take my turn off when engine safe mode message came on. I then realized that i had no power even though lights, radio, and a/c was still on. Not being able to accelerate i coasted the vehicle to side of hwy as far as possible, turned key to off and than back on and it started up. I was able to get home without further problem and back to work. Unfortunately i have a [redacted]…

    ODI 10457105

  • March 30, 2012 · 109,000 miles

    Engine And Engine Cooling

    Tl* the contact owns a 2006 ford expedition. The contact stated that while driving 55 mph, the vehicle stalled in the middle of the road. The vehicle was safely merged onto the shoulder and the contact turned the engine off. The check engine light illuminated prior to the failure. The vehicle was taken to the dealer, who replaced the oxygen sensor, sparks plugs, and engine coils. The failure continued. The vehicle…

    ODI 10456870

  • March 9, 2012 · 105,300 miles

    Engine And Engine Cooling

    I bought my truck used from a dealership in january 2012. I had driven it for about 8 weeks when it completely died on me at a stop light before take off. Everything was on except it would not go and the message came up saying fail safe mode. It did it a couple weeks later taking off from a stop sign and then after that it seemed to do it once a month. This last time on friday october 26, 2012 it did it while i was…

    ODI 10483436

  • February 8, 2012 · 55,000 miles

    Engine And Engine Cooling

    Engine fail safe mode resulting in complete shutdown while going at highway speed. Vehicle losses all power and has to be restarted. *tr

    ODI 10447516

  • February 1, 2012 · 90,000 miles

    Engine And Engine Cooling

    Tl* the contact owns a 2006 ford expedition. The contact stated that the vehicle would only shift into reverse. Upon examining the vehicle, the contact noticed that a wiring harness within the engine melted against the exhaust manifold. The vehicle was taken to an authorized dealer and the contact was informed that the wiring harness needed to be replaced. The vehicle was not repaired. The manufacturer was made…

    Fire reported

    ODI 10446777

  • January 17, 2012 · 160,000 miles

    Engine And Engine Cooling

    Tl* the contact own a 2006 ford expedition. The contact stated was driving 25 mph when the vehicle stalled without warning. The vehicle was restarted and the contact drove the vehicle home. The contact attempted to restart the vehicle but to no avail. The contact had the vehicle towed to a dealer where the dealer replaced the cam phasers. The failure mileage was 160,000. The vin was not available.

    ODI 10444400

  • January 5, 2012 · 86,280 miles

    Engine And Engine Cooling · Vehicle Speed Control

    Tl* the contact owns a 2006 ford expedition. The contact stated that while driving 15 mph on the highway, the vehicle unexpectedly stalled. An engine fail safe light also began to illuminate on the instrument panel. Both the dealer and manufacturer were notified, but denied any assistance with repairs of the failure. The vehicle was on 01/06/12 at the contact's expense. The approximate failure and current mileages…

    ODI 10442650

  • November 28, 2011 · 38,000 miles

    Engine And Engine Cooling

    A warning light "engine fail safe" flashed and the engine stalled. I was fortunate there was a parking lot i could force the vehicle into, as i was in morning rush hour traffic in houston tx, and was almost rear ended. Apparently this is a very common problem among the 2006 ford expedition, i have done some research on-line and viewed many complaints about this same thing. I checked with one auto shop, which says…

    ODI 10437574

  • November 26, 2011 · 80,000 miles

    Electrical System · Engine And Engine Cooling · Vehicle Speed Control

    While driving my 2006 ford expedition eddie bauer, the engine completely shuts off. Sometimes while sitting idle and other times while driving 70 mph on the interstate. Tonight, within 1 hour this happened about 15 times where the engine cut off, i lost power steering, had to roll over to the shoulder, turn the key off and back on to restart...sometimes it would take up to 10 minutes to restart. I was lucky we were…

    ODI 10437417

  • November 23, 2011 · 71,200 miles

    Engine And Engine Cooling

    Tl* the contact owns a 2006 ford expedition. The contact was driving approximately 10 mph approaching a stop signal and from a complete stop, the engine stalled when the warning light illuminated; however, the vehicle restarted within a few minutes. The vehicle was taken to an independent mechanic and was currently being diagnosed. The manufacturer was made aware of the failure. The approximate failure mileage was…

    ODI 10436883

  • November 15, 2011

    Engine And Engine Cooling

    Tl* the contact owns a 2006 ford expedition. The contact was driving 55 to 65 mph when the engine safe mode warning light illuminated and the engine stalled. The vehicle restarted after the failure. The failure occurred seven different times. The vehicle was taken to the dealer. The manufacturer was also notified. The vehicle was not repaired and the vin was unknown. The failure and current mileages were unknown.

    ODI 10456443

  • November 1, 2011

    Engine And Engine Cooling

    2006 ford expedition. Consumer states mechanical issues with the vehicle *tgw the dealer informed the consumer a new engine was needed. The warranty dept. Denied the consumers claim, because maintenance records could not be produced. The consumer's house was set on fire, and therefore, no maintenance records were available. *jb

    ODI 10437008

  • November 1, 2011 · 80,000 miles

    Engine And Engine Cooling

    Tl* the contact owns a 2006 ford expedition. The contact stated that the vehicle would stall at anytime while in motion. The dealer attempted to repair the defect, but the failure recurred. The manufacturer was not contacted. The failure and the current mileage was 80,000. Updated 02/22/12*lj the consumer stated the vehicle would stall while at a stop. Updated 03/01/12

    ODI 10433992

  • October 22, 2011 · 73,000 miles

    Engine And Engine Cooling

    The vehicle has done this twice. Driving along, it goes into fail safe mode and stops dead. The manual states this is a coolant issue which was not the case; there was adequate coolant. Doing some research on various internet sites, this seems to be a common problem with 2006 expeditions. I called ford customer service and was told they were unaware of a problem. I find this difficult to believe given all the sites…

    ODI 10435469

  • October 14, 2011 · 117,000 miles

    Engine And Engine Cooling

    Tl* the contact owns a 2006 ford expedition. The contact stated that when driving at various speeds, the engine safety mode failure warning lamp would illuminate and the vehicle would stall. The contact mentioned that the failure occurred three times. The vehicle was taken to the dealer who was unable to duplicate the failure. The manufacturer was not made aware of the failure and the vehicle was not repaired. The…

    ODI 10440029

  • October 12, 2011 · 168,000 miles

    Engine And Engine Cooling

    Tl* the contact owns a 2006 ford expedition. The contact was driving 20 mph the vehicle stalled with the illumination of the check engine fail safe light. The vehicle was not taken to the dealer to be diagnosed or repaired. The failure and the current mileage was 168,000.

    ODI 10429638

  • September 26, 2011 · 94,680 miles

    Engine And Engine Cooling

    Took my 2006 ford expedition limited to the dealership for a tune-up and was told of an issue that the 5.4l engines have. They mentioned that some 2004-2008 f-150, 2006-2008 mark lt, 2005-2008 f-super duty, expedition, and navigator, with 5.4l 3-v engine; 2005-2008 mustang, 2006-2008 explorer, mountaineer, and 2007-2008 explorer sport trac with 4.6l 3-v engine; 2005-2008 f-super duty, 2006-2008 and f-stripped…

    ODI 10427845

  • August 23, 2011 · 80,000 miles

    Engine And Engine Cooling

    Tl* the contact owns a 2006 ford expedition. The contact was driving 45 mph when the engine stalled without warning. The vehicle restarted after the failure but was not taken to the dealer for inspection or repairs. The manufacturer was contacted but provided no assistance. The vehicle was not repaired. The vin was unavailable. The failure and current mileages were 80,000.

    ODI 10421151

  • July 15, 2011 · 82,000 miles

    Engine And Engine Cooling

    Tl* the contact owns a 2006 ford expedition. The contact stated that the vehicle stalled while driving at various speeds and the engine safe mode warning indicator illuminated. The contact stated that the failure occurred on three prior occasions. The vehicle was taken to an authorized dealer, who was unable to diagnose the failure. The manufacturer was made aware of the failure, but offered no assistance and…

    ODI 10447835

  • July 12, 2011 · 90,000 miles

    Engine And Engine Cooling

    Tl* the contact owns a 2006 ford expedition. While driving approximately 40 mph, the engine stalled with the illumination of the check engine warning indicator. The engine restarted after waiting a few moments. The same failure recurred four times. The vehicle was taken to an authorized dealer and they were unable to duplicate the problem. The manufacturer was notified of the malfunction. The approximate failure…

    ODI 10441128

  • July 1, 2011 · 40,000 miles

    Engine And Engine Cooling

    Tl* the contact owns a 2006 ford expedition. While driving approximately 25 mph, the vehicle stalled without warning. The failure recurred sporadically and at different speeds. The vehicle was taken to an independent mechanic for diagnostics. The contact was not aware of the repairs needed. The vehicle was not repaired. The vin was not available. The approximate failure mileage was 40,000.

    ODI 10444512

  • June 14, 2011 · 104,000 miles

    Engine And Engine Cooling

    Tl*the contact owns a 2006 ford expedition. The contact stated that carbon built up around the spark plugs and he was unable to remove it since one of the spark plugs fractured in half and the other part was stuck in the vehicle; however, if he were to remove them it would cause serious damage to the engine. The dealer advised the contact to bring the vehicle in for service. The vehicle was not repaired. The…

    ODI 10407257

  • April 3, 2011 · 76,000 miles

    Automatic Transmission · Engine And Engine Cooling

    Vehicle has been sputtering when accelerating at about 40mph. Spark plugs are "seered" and ford mechanic tells us its a known problem, but not covered under the warranty because spark plugs are considered maintenance. The manual says we the scheduled maintenance is 100,000 miles and we are only at 76,000. If they are known to be faulty and we are not near the scheduled/recommended mainteance then shouldn't this be a…

    ODI 10394140