2003 Ford Expedition Suspension Problems
- 14
- Owner complaint records in our dataset
Records are owner complaints, not a measured failure rate.
Owner complaint recordsComplaint records reflect reports in our dataset and do not measure how frequently the problem occurs across all vehicles.
Among these 14 stored complaint records:
- 3 indicate a crash
- 1 indicate injury
- 0 indicate fire
Mileage in stored records
| Band | Records |
|---|---|
| 1–30k mi | 6 |
| 100–150k mi | 2 |
| 150–400k mi | 2 |
Complaint records
Owner-submitted complaint content, presented as stored.
Suspension
My 2003 ford expedition has a rear end problem and its now roaring while i'm on the highway. I notice there was a recall on this because this is very dangerous to the consumer. I also notice there are other ford expedition has the same problem. Please see recall bulletin for this item#10016789.nhtsa item number 050618. Replacement# 05126.
ODI 10970368
Engine · Power Train · Suspension
TRANSMISSION SLIPPING @ 30-50 MPH. *TR
ODI 10678912
Air Bags · Steering · Suspension · Wheels
Lost control, hit parked car and tree, front end damage, driver side fender, driver door, driver received laceration to forehead and two fractured ribs. Air bags did not deploy. *tr
Crash reported · 1 injury
ODI 10537603
Steering · Suspension · Wheels
I was driving on the interstate on 7/27/12 to take my daughter back to her mother, as i had my daughter during summer visitation. Half-way into my trip (525 miles one-way) it started to rain and i hydro-planed, resulting in a one-car accident. I slid from the inner lane (passing lane), across the outer lane, into the shoulder and crashed into a guard-rail. If not for the guard-rail, my vehicle would have fallen…
Crash reported
ODI 10468091
Suspension
Tl* the contact owns a 2003 ford expedition. The contact stated while driving 45 mph the vehicle failed to absorb impact from driving over a pot hole. The contact believed the failure may be caused by the upper and lower control arm bushing and ball joints prematurely wearing out. The vehicle was not taken to the dealer, but the manufacturer was contacted. The vehicle was not repaired. The failure and current…
ODI 10416553
Suspension
Tl*the contact owns a 2003 ford expedition. While driving less than 30 mph, the contact heard a loud pop and assumed that a tire blew out. The vehicle dropped and began to scrape the road surface. She was able to maneuver the vehicle off the road. The vehicle was towed to the service station and it was discovered that the a-arm axle ruptured. The failure and current mileages were less than 111,000. Updated 11/17/08…
ODI 10243115
Steering · Suspension
Front tires were wearing unevenly on outside edges. Took to tire shop for rotate and alignment. They said that alignment was outside manufacturer specs, but there is no adjustment mechanism on vehicle. Special camber/castor adjuster kit must be purchased and installed at my expense to allow adjustment. Otherwise tires will continue to wear unevenly and cause premature failure and possible loss of vehicle control. *jb
ODI 10110054
Axle Assembly · Body · Interior Lighting · Power Window Devices And Controls · Suspension · Tie Rod Assembly
Dt: the drivers side tie rod has broken twice. Both times was without warning. The dealer has fixed it once and now it is back to the dealer for the second time for same problem. The manufacturer took information from the consumer, but she has not heard back from them. *jb passenger side rear window does not go down from master switch. Door ajar light does not go off. Left front ball joint separated, then vehicle…
Crash reported
ODI 10121387
Cooling System · Electrical System · Rotor · Suspension
While making a stop, the check engine light appeared on the dashboard and remained on. The vehicle was taken to the dealer for inspection numerous times, but the mechanic could not duplicate the problem. While applying the brake pedal, the vehicle failed to stop completely. The vehicle was taken to the dealer for inspection, and the mechanic determined that the brake rotors needed to be replaced. *ak when stopping,…
ODI 10115182
Suspension
At 65-75 mph car feels like tires are going to fall off "bad vibration." *la
ODI 10046999
Suspension · Tires
Vibration from tires when driving on highway.*ak
ODI 10036974
Suspension
When driving 55 mph and over there was loud noise coming from the engine compartment. This noise was accompanied by severe vibration in the steering wheel and the entire vehicle. Dealer informed the consumer that the vibration was normal. *ak
ODI 10050221
Pressure Monitoring And Regulating Systems · Suspension
2003 FORD EXPEDITION LEMON VIBRATION. 8AK
ODI 10033380
Mechanical · Service Brakes, Air · Suspension
When turning left or right loud grinding noise- has been serviced 4 times and after the last time it stopped, but has since returned. Also, excessive amounts of brake dust on wheels, and they are making noises. Also as if they need to be changed and theres only 4000 miles on the truck. *ak
ODI 10031183