2015 Ford Expedition Fuel/Propulsion System Problems
- 16
- Owner complaint records in our dataset
Records are owner complaints, not a measured failure rate.
Owner complaint recordsComplaint records reflect reports in our dataset and do not measure how frequently the problem occurs across all vehicles.
What owners report
- throttle body · 10 records
- lost power · 5 records
Mileage in stored records
| Band | Records |
|---|---|
| 30–60k mi | 7 |
| 60–100k mi | 6 |
| 1–30k mi | 2 |
Complaint records
Owner-submitted complaint content, presented as stored.
Engine · Fuel/Propulsion System
I was driving at approximately 50 mph, in a steady-state in mild traffic, when the wrench icon in the left-side of the dashboard lit up momentarily and the vehicle lost all power. The engine was still running but was unresponsive. I had to coast to a stop, turn it off then re-start the vehicle. It did so again upon driving it on monday aug 19. Ford was contacted and denied the issue, even though this exactly mimics…
ODI 11245028
Engine · Fuel/Propulsion System · Power Train
Engine stalls out at freeway speeds and produces a p2112 code throttle body stuck closed. Engine cuts out completely. Has happened five times. Mileage 55234 only. Engine restarts normally until next incident. Car produced at louisville kentucky truck plant which produced the defective electronic throttle bodies included in the ford recall campaign 16b32.
ODI 11165025
Fuel/Propulsion System
When driving on highway the engine goes into limp mode 3mph max. Displays wrench symbol on instrumentation panel.. No possible acceleration possible.. Very dangerous if you were entering an intersection on highway. I could see possible fatalities. If you shut off engine and restart will run as normal for about a mile than same scenario. Ran code showed "p2112" faulty throttle body. If you were crossing a highway i…
ODI 11129112
Fuel/Propulsion System
55,000 miles. Orange wrench warning light came on driving through town about 25 mph. Lost power and coasted across the rail road tracks in town. Vehicle was still running, however had no power and minimal idle speed. I got pulled off to the side of the road. Diagnostic said to check manual. I tried to do that and the vehicle wasn't idling the best, so i shut it off. I was at a busy intersection and was on my way to…
ODI 11124597
Fuel/Propulsion System
Well known throttle body issue across the ford line. Not covered under lifetime warranty. Sudden deceleration and stoppage due to electronic throttle body failure.
ODI 11119844
Engine · Fuel/Propulsion System · Power Train
In the past week, on 2 separate occasions, my 2015 ford expedition has stalled while driving. First instance, while driving approx. 45mph on small country road and accelerating, vehicle stalled and came to a rolling stop, with service indicator light and "see manual" illuminated on dashboard. Once stopped and shifted into park, vehicle started and drove again normally. Second instance (approx. 2 days later), while…
ODI 11096463
Fuel/Propulsion System
Electronic throttle body etb, dephi 6. The car all of a sudden drops the speed to an idle, produces a warning wrench on dash (p2112 or 2111 code) the vehicle loses power and barley moves. This happened about 3 times while i was driving with my family in car. I was able to pull off the road and restart the vehicle. Luckily i was not towing my trailer at the time. This happened on a road trip and it was fix under…
ODI 11080255
Fuel/Propulsion System
Vehicle in motion on freeway at speed (70mph approx.) and suddenly lost power w/check engine light (orange wrench) coming on. Vehicle had no power/acceleration and seemed to only idle. Was able to coast to right shoulder. Shut engine off and waited for a few moments and turned back on, started up, and appeared to work normally, allowing us to continue on to destination.
ODI 11063021
Fuel/Propulsion System
My wife was driving our kids home on the interstate when the car went into limp mode. She was scared and didn't know what to do. We brought it to the ford store and they replaced the throttle body.
ODI 11030435
Fuel/Propulsion System
At about 56000 miles, while driving down the road at about 55 mph, the wrench light came on and the truck went into, what i now know as, crawl home mode. I had to drift to the side of the road and restart the truck. About a week later the same thing happened. To it to the dealership where is was purchased and was told that it is a faulty throttle body. I was told that it is not covered under any warranty and would…
ODI 11024563
Fuel/Propulsion System
Filed complaint few months back, 10985979. Sudden loss of power. Started to happen again, this time it happened around 15 times in a 200 mile period. Happened during all driving conditions, city and highway, from a stop to highway speeds. No warring just full loss of power. Shut truck off, restarted and ran normally for 6-10 miles then would shut down again. After the 3rd time a check engine light came on. Drove to…
ODI 11001355
Fuel/Propulsion System
Vehicle lost power while driving on city street. No warning prior to losing power. Had a "wrench" light appear on dash. I had to coast to side of the road. Had i been on the highway, merging, or turning in front of approaching vehicles, there is a high probability there would have been an accident. I attached a tester on the vehicle and p2112 defect code appeared indicating a stuck throttle actuator control. This…
ODI 10984149
Engine · Fuel/Propulsion System
1/28/17 driving 65 mph on a florida highway (not on cruise control) the throttle/gas peddle sensor (throttle body) shuts off the gas to the engine and the car slows to a stop. This is in the middle of traffic. We manage to pull to the side of the highway, turn the car off and on and the problem disappears for another [redacted] the car to a ford dealer and they replace the throttle body for $500. I am . Out of…
ODI 10971425
Fuel/Propulsion System
Total loss of power while driving - must pull over and restart
ODI 10876863
Fuel/Propulsion System
[xxx] information redacted pursuant to the freedom of information act (foia), 5 u.s.c. 552(b)(6). *tr
ODI 10840308
Electrical System · Engine · Fuel/Propulsion System
01 june 2015 driving on interstate 10 from beaumont texas i entered a heavy rain storm, traffic slowed down to about 50 m.p.h. In a 70 m.p.h. Speed zone. I passed a tractor trailer, when the mist from the truck and the rain hit my vehicle, my engine lost power. I removed my foot from the gas, after a few hundred yards the power came back but my engine light was on. The problem happened 4 or 5 times thru louisiana…
ODI 10766489